EXPERIMENTAL STUDY ON A SOLAR-HEATED BIOGAS DIGESTER USING SHALLOW SOLAR POND IN COLD CLIMATE

Abd El-Wahab, M.K.; Hassan, M.M.A; Tawfik, M.A.; Abd Allah, W. E.

doi:10.21608/mjae.2017.97503

EXPERIMENTAL STUDY ON A SOLAR-HEATED BIOGAS DIGESTER USING SHALLOW SOLAR POND IN COLD CLIMATE

Document Type : Original Article

Authors

¹ Professor Emeritus, Agric. Eng. Dept., Fac. of Agric., Zagazig Univ., Egypt.

² Assistant. Prof., Agric. Eng. Dep., Fac. of Agric., Zagazig Univ., Egypt.

³ Lecturer, Agric. Eng. Dept., Fac. of Agric., Zagazig Univ., Egypt.

10.21608/mjae.2017.97503

Abstract

In northern Egypt, the ambient temperature almost below 20°C during winter months, which is insufficient for the anaerobic digestion (AD) and affecting negatively the biogas yield, especially for the floating dome digester(Indian model) due to the heat losses through the gas holder. Since the slurry temperature is a crucial factor for the AD rate, this investigation aims to heat a concrete pre-constructed floating dome biogas digester (Family-scale digester) during winter season for enhancing the fermentation rate by utilizing the extracted heat of integrated shallow solar pond (SSP) using dairy cattle dung comparing to a previous work of un-heated digester. The solar-heated digester was evaluated under the same operating conditions of the un-heated digester except the slurry temperature and similar values of both the solar radiation intensity and ambient temperature during 30 days without feeding as a digestion time taking into consideration the slurry temperature, pH, daily, cumulative (m³/month) and specific (m³/kg _VS) biogas yield as well as the total net gained energy. The obtained results revealed that, the average slurry temperature of the solar-heated biogas digester system increased by 12.3°C which led to increase the average daily, cumulative and specific biogas yield by about 129 % higher than the un-heated digester with average methane content of 70% and total net gained energy of 553.1 MJ/month.

Keywords

Main Subjects

Biosystems Engineering

References

Abd Allah, W. E. (2016). Enhancing the extracted heat from the shallow solar pond to be used in biogas production. phD thesis, Fac. of Agric., Zagazig Univ., Egypt

Abd Allah, W. E., M. K. Abd El-Wahab, M. M. A. Hassan and M. A. Tawfik (2016). Study on biogas unit using dairy cattle dung during winter in Egypt. Zagazig J. of Agric. Eng., 43 (3): 1051-1057.

Al Seadi, T., D. Rutz , H. Prassl, M. Köttner, T. Finsterwalder, S. Volk and Janssen R.(2008). Biogas Handbook: more about anaerobic digestion (AD) . Esbjerg: University of Southern Denmark, 23 p.

Anand, R.C. and R. Singh (1993). Simple technique, charcoal coating around the digester, improves biogas production in winter. Bioresour. Technol., 45(2): 151-152.

Bansal, N. K., S. C. Bhand, S. Ram and K. K.A. Singh (1985). Study of a greenhouse concept on conventional biogas systems for enhancing biogas yield in winter months. Int. J. of Energy Res., 92(2): 119-128.

Chae, K.J., A.M. Jang, S.K. Yim and I.S. Kim ( ).The effects of digestion temperature and temperature shock on the biogas yields from the mesophilic anaerobic digestion of swine manure. Bioresour. Technol., 88(1):1-6.

Chenglin, M., L. Rongping and L. Xiujin (2009).Integrated system of greenhouse and solar heater for anaerobic digestion of excess activated sludge. Transactions of the Chinese Soc. of Agric. Eng., 25 (9): 210–214 (in Chinese).

Dong, F. and J. Lu (2013). Using solar energy to enhance Biogas production from livestock residue - A case study of the Tongren Biogas engineering pig farm in South China. Energy, 57: 759-765.

El-Mashad, H.M., W. K. van Loon, G. Zeeman, G.P. Bo and G. Lettinga (2004). Design of a solar thermophilic anaerobic reactor for small farms. Biosys. Eng., 87(3): 345-353.

El-Sebaii, A. A. (2005). Thermal performance of a shallow solar-pond integrated with a baffle plate. Appl. Energy, 81(1): 33–53.

FAO (2013) Production year book. The United Nations, http://faostat3.fao.org/browse/Q/QA/E

Ganesh, S. and S. Arumugam (2016). Performance study of a laboratory model shallow solar pond with and without single transparent glass cover for solar thermal energy conversion applications. Ecotoxicol and Environ Safety, 134:462-466.

Gupta, R.A., S.N. Rai and G.N. Tiwari (1988).An improved solar assisted biogas plant (Fixed dome digester): A transient analysis. Energy Convs and Manag.,1988; 28(1):53-57.

Jiao, Y. Z., P. F. Li, G. Li, Q. G. Zhang, P. Ding, S. P. Wang, Z. Gao, S. Du and C. He (2016). Design and preliminary experimental research on a new biogas fermentation system by solar heat pipe heating. Int. J. Agric. & Biol. Eng., 9(2): 153－162.

Kitamura, Y., P. Dan, L. Gautz and T. Liang (2007). A rotational hot gas heating system for bioreaetors. Biosys. Eng., 98(2): 215−223.

Kumar, K. V. and R. K. Bai (2008). Solar greenhouse assisted biogas plant in hilly region – A field study. Sol. Energy, 82 (10): 911–917.

Kumar, K. V. and R. K. Bai (2005). Plastic biodigesters - a systematic study. Energy For Sust. Develop., 9(4): 40-49.

Li, J. Y., J. Li , Q. Y. Liu and H. Zheng (2014). Design of the solar energy-heated biogas digester. Adv. Mater. Res., 953-954:103-106.

Lu, Y., Y. Tian, H. Lu, L. Wu and X. Li (2014). Study of solar heated biogas fermentation system with a phase change thermal storage device. Appl. Therm. Eng., 88: 418– 424.

Murphy, J. D. and T. Thamsiriroj (2013). Fundamental science and engineering of the anaerobic digestion process for biogas production. In: Wellinger A, Murphy J, Baxter D. (Ed.), editors. The biogas handbook: science, production and applications. Cambridge: Woodhead Publishing Ltd., pp. 104-130.

Nijaguna, B.T. (2009). Biogas technology. New Delhi: New Age International (P) Ltd.47 p.

Santosh, Y., T.R. Sreekrishnan, S. Kohli and V. Rana (2004). Enhancement of biogas production from solid substrates using different techniques–a review. Bioresour. Technol., 95(1): 1-10.

Shi, H. X., K. Xu and T. Lv (2013). Heating systems combined with solar energy and lake water source for biogas digester. Appl. Mech. and Mater, 291: 1684-1689.

Subramanyam, S.(1989). Use of solar heat to upgrade biogas plant performance. Energ. Convs and Manag., 29(1): 73-75.

Wang, L., B.N. Zhu, H.R. Yuan, Y.P. Liu, D.X. Zou and X. J Li (2016).Comparative investigations on pilot-scale anaerobic digestion of food waste at 30°C and 35°C. Int. J. Agric. and Biol. Eng., 9(1): 109－1187.

Xu, Z., H. Wu and M. Wu (2010). Energy performance and consumption for biogas heat pump air conditioner. Energy, 35(12): 5497-5502.

Zeeman, G. and G. Lettinga (1999).The role of anaerobic digestion in closing the water and nutrient cycle at community level. Water Sci. Technol., 39(5):187-194.

Zhong, Y., M. B. Roma , Y. Zhong, S. Archer, R. Chen, L. Deitz, D. Hochhalter, K. Balaze, M. Sperry, E. Werner and D. Kirk (2015). Using anaerobic digestion of organic wastes to biochemically store solar thermal energy. Energy, 83: 638-646.

Zhu, X. H., C. Zhong and Z. B. Jiang (2013). Solar biogas digester and wetland-pond system for rural wastewater treatment. Adv. Mater. Res., 800: 610-613.