EFFECT OF USING AN ELECTROMAGNETIC FIELD ON THE PERFORMANCE OF REVERSE OSMOSIS MEMBRANES IN BRACKISH WATER

Articles in Press

Document Type : Original Article

Authors

1 MSc Stud. in Ag. Eng. Dept., Fac. of Ag., Ain Shams U. Qalyubia, Egypt.

2 Prof. of Ag. Eng. Dept., Fac. of Ag., Ain Shams U. Qalyubia, Egypt.

3 Consultant to the Chairman of the Board of the Engine Factory, AOI, Cairo, Egypt.

4 Freelance Electronics Engineer. Cairo, Egypt.

5 Lect. of Soil Sci. Dept., Fac. of Ag., Ain Shams U. Qalyubia, Egypt.

Abstract

Reverse osmosis membranes have long been one of the most popular and effective methods for desalination, due to their ease of operation and high efficiency in salt separation. However, scaling remains one of the most significant challenges associated with these membranes, as it can reduce flow rates and cause membrane damage. Therefore, over the decades, the electromagnetic field has been widely used in water treatment processes to address such issues. This study involved two experiments: the first was conducted without the application of an electromagnetic field before the membrane, and the second with an electromagnetic field applied before the membrane. Both experiments were conducted in the research laboratory of the Department of Soil and Water Sciences, Faculty of Agriculture, Ain Shams University.
The objective of the study was to investigate the effect of an electromagnetic field generated through a coil of electrically conductive wire, powered by a frequency generator circuit operating at 150 kHz. The results showed an increase in salt rejection in the freshwater outlet, a decrease in sodium and chloride ions in both the freshwater and concentrate streams (as determined by elemental analysis), and a reduction in the percentage of freshwater recovery.

Keywords

Main Subjects

References

Alwan, A. A., Ahmed, S., Nwokoye, A., Alhendi, A. A., Ibrahim, O., and Alhseinat, E. (2024). Recent advances in the application of magnetic/electromagnetic field for water desalination. Current Trends and Future Developments on (Bio-) Membranes, 427-459. https://doi.org/10.1016/B978-0-323-99311-1.00010-6
Antony, A., Low, J. H., Gray, S., Childress, A. E., Le-Clech, P., and Leslie, G. (2011). Scale formation and control in high-pressure membrane water treatment systems: A review. Journal of membrane science, 383(1-2), 1-16. https://doi.org/10.1016/j.memsci.2011.08.054
Bisbee, D. (2003). Pulse-Power Water Treatment Systems for Cooling Towers. Energy Efficiency & Customer Research & Development Sacramento Municipal Utility District.
Beaty, H. W.  (2001). Chapter One, Basic Network Analysis, HANDBOOK OF ELECTRIC POWER CALCULATIONS. McGraw-Hill Professional, New York, pp. 14-16, 19 and 23-27
Chase, D. V. (2022). Chapter Four, Volumetric Flowrate, Velocity and the Continuity Equation, Open Educational Resource: Civil Engineering Course Notes. Pp. 182.
Chen, L., Xu, P., and Wang, H. (2020). Interplay of the factors affecting water flux and salt rejection in membrane distillation: A state-of-the-art critical review. Water, 12(10), 2841. https://doi.org/10.3390/w12102841
Conway, J.M. (2002). Electronic Scale Treatment, a Commercial and Industrial Article, Clear Water Enviro Technologies, Available from: http://www.wqpmag. com/sites/default/files/_P.14-16%20Scale%204_02.pdf
Du, X., Perera, H., Ahasan, T., Wang, Y., Shu, F., Wang, H., ... and Xu, P. (2025). Mechanisms of electromagnetic field control on mineral scaling in brackish water reverse osmosis: Combined homogenous and heterogeneous nucleation. Separation and Purification Technology, 355, 129630. DOI: 10.1021/acs.est.4c14658
Du, X., Jiang, W., Wang, Y., Shu, F., Wang, H., Vazquez, D., ... and Xu, P. (2024). Numerical modeling of electromagnetic field spatiotemporal evolution to evaluate the effects on calcium carbonate crystallization. Desalination, 592, 118128. https://doi.org/10.1016/j.desal.2024.118128
Geise, G. M., Lee, H. S., Miller, D. J., Freeman, B. D., McGrath, J. E., and Paul, D. R. (2010). Water purification by membranes: the role of polymer science. Journal of Polymer Science Part B: Polymer Physics, 48(15), 1685-1718. https://doi.org/10.1002/polb.22037
Greenlee, L. F., Lawler, D. F., Freeman, B. D., Marrot, B., and Moulin, P. (2009). Reverse osmosis desalination: water sources, technology, and today's challenges. Water research, 43(9), 2317-2348. https://doi.org/10.1016/j.watres.2009.03.010
Huchler, L. A., Mar, P. E., and Lawrenceville, N. J. (2002, October). Non-chemical water treatment systems: histories, principles and literature review. In International Water Conference (pp. 02-45). Available from: https://www.thomasnet.com/pdf.php?prid=100429
Kucera, J. (2023). Chapter two, Principles and Terminology, Reverse osmosis. John Wiley & Sons. Pp. 35 and 38.
Lee, H. J., Halali, M. A., Baker, T., Sarathy, S., and de Lannoy, C. F. (2020). A comparative study of RO membrane scale inhibitors in wastewater reclamation: Antiscalants versus pH adjustment. Separation and Purification Technology, 240, 116549. https://doi.org/10.1016/j.seppur.2020.116549
Lee, J., Ren, X., Yu, H. W., Kim, S. J., and Kim, I. S. (2010). Membrane biofouling of seawater reverse osmosis initiated by sporogenic Bacillus strain. Environmental Engineering Research, 15(3), 141-147. https://doi.org/10.4491/eer.2010.15.3.141
Lin, L., Jiang, W., Xu, X., and Xu, P. (2020). A critical review of the application of electromagnetic fields for scaling control in water systems: mechanisms, characterization, and operation. NPJ Clean Water, 3(1), 25. https://doi.org/10.1038/s41545-020-0071-9
MOERE, (2025). Ministry of Electricity and Renewable Energy.
Matin, A., Laoui, T., Falath, W., and Farooque, M. (2021). Fouling control in reverse osmosis for water desalination & reuse: Current practices & emerging environment-friendly technologies. Science of the Total Environment, 765, 142721. https://doi.org/10.1016/j.scitotenv.2020.142721
Nair, M., and Kumar, D. (2013). Water desalination and challenges: The Middle East perspective: a review. Desalination and Water Treatment, 51(10-12), 2030-2040. https://doi.org/10.1080/19443994.2013.734483
Pearson, J. L., Michael, P. R., Ghaffour, N., and Missimer, T. M. (2021). Economics and Energy Consumption of Brackish Water Reverse Osmosis Desalination: Innovations and Impacts of Feedwater Quality. Membranes, 11(8), 616. https://doi.org/10.3390/membranes11080616
Penteado de Almeida, J., Stoll, Z., and Xu, P. (2023). An Alternating, Current-Induced Electromagnetic Field for Membrane Fouling and Scaling Control during Desalination of Secondary Effluent from Municipal Wastewater. Water, 15(12), 2234. https://doi.org/10.3390/w15122234
Razavi, B. (2021). Fundamentals of Microelectronics. John Wiley & Sons, pp. 381-384 and 660-661
Saksono, N., Bismo, S., Widaningroem, R., and Manaf, A. (2011). Formation of CaCO3 particle and conductivity of Na2CO3 and CaCl2 solution under magnetic field on dynamic fluid system. Makara Journal of Technology, 15(1), 14. https://doi.org/10.7454/mst. v15i1.862.
Sheikholeslami, R. (2004). Assessment of the scaling potential for sparingly soluble salts in RO and NF units. Desalination, 167, 247-256. https://doi.org/10.1016/j.desal.2004.06.134
Schoenbach, K. H., Alden, R. W., and Fox, T. J. (1996, June). Biofouling prevention with pulsed electric fields. In Proceedings of 1996 International Power Modulator Symposium (pp. 75-78). IEEE. 10.1109/MODSYM.1996.564454
Skoog D. A.; West D. M., and Holler F. J. (1996). Fundamentals of Analytical Chemistry, 7th Edition, Thomson Learning, Inc, USA.
Taherinejad, M., Derakhshan, S., and Yavarinasab, A. (2017). Hydrodynamic analysis of spiral wound reverse osmosis membrane recovery fraction and permeate water flow rate. Desalination, 411, 59-68. https://doi.org/10.1016/j.desal.2017.02.009
Thompson, J., Lin, N., Lyster, E., Arbel, R., Knoell, T., Gilron, J., and Cohen, Y. (2012). RO membrane mineral scaling in the presence of a biofilm. Journal of Membrane Science, 415, 181-191. https://doi.org/10.1016/j.memsci.2012.04.051
Rouina, M., Kariminia, H. R., Mousavi, S. A., and Shahryari, E. (2016). Effect of electromagnetic field on membrane fouling in reverse osmosis process. Desalination, 395, 41-45. https://doi.org/10.1016/j.desal.2016.05.009
Misr Journal of Agricultural Engineering

Articles in Press, Accepted Manuscript
Available Online from 11 August 2025

Files

Share

How to cite

Statistics